疣孢漆斑菌Myrothecium verrucaria GH-01漆酶的纯化和酶学性质研究

doi:10.13560/j.cnki.biotech.bull.1985.2015.08.018

摘要/Abstract

摘要： 疣孢漆斑菌具有生长周期短,分泌漆酶酶活高等特点。利用已分离得到的疣孢漆斑菌GH-01（Myrothecium verrucaria GH-01）发酵产生粗酶液。进而通过分级沉淀、透析和层析的方法对漆酶粗酶液进行纯化。SDS-PAGE和Native-PAGE结果表明纯化可获得具有漆酶活性的单体蛋白。酶学性质研究表明,该漆酶催化最适温度为40℃,在底物ABTS存在条件下的最适pH值为4.0,且在低温及碱性条件具有较好的稳定性。此外通过漆酶对4大类染料脱色能力的研究,发现该漆酶对偶氮类的橙黄Ⅰ和蒽醌类的茜素红脱色有较好的脱色效果,反应1 h脱色率达80%以上;对三苯甲烷类的碱性品红脱色能力较弱,脱色率只能达到20%左右;脱色率最差的是杂环类的亚甲基蓝。在含10 U漆酶的体系中,对50 mg/L的染料降解效果相对最佳。

关键词: 疣孢漆斑菌漆酶, 纯化, 酶学性质

Abstract: Myrothecium verrucaria has the advantages of short growth cycle and high enzyme activity of secreting laccase. In this study, the crude enzyme was produced by the M. verrucaria GH-01 obtained by separation. Further we purified the crude enzyme by fractional precipitation, dialysis and chromatography. The results of SDS-PAGE and Native-PAGE indicated that the monosome protein with laccase activity was obtained by purification. The study of enzymatic properties of laccase showed that the optimal temperature of catalyzed reaction for laccase was 40℃, and the laccase activity against ABTS showed a maximum at pH4.0. It had the favorable stability under the low temperature and alkaline conditions. Besides, studying the laccase decolorizing of 4 representative dyes demonstrated that the laccase decolorizing rate for orange I of azo dyes and alizarin red of anthraquinone class was the highest with decolorizing rate over 80% by 1 h, lower for fuchsin of triphenylmethane class with decolorizing rate only 20% and lowest for methylene blue of heterocyclic class. In 10 U laccase system, the decolorizing degree of the 50mg/L dye concentration was optimal.

Key words: Myrothecium verrucaria GH-01, purification, enzymatic properties

王紫娟, 赵敏. 疣孢漆斑菌Myrothecium verrucaria GH-01漆酶的纯化和酶学性质研究[J]. 生物技术通报, 2015, 31(8): 119-124.

Wang Zijuan, Zhao Min. Purification and Enzymatic Properties of Laccase from Myrothecium verrucaria GH-01[J]. Biotechnology Bulletin, 2015, 31(8): 119-124.

参考文献

[1] Thurston CF. The structure and function of fungal laccases[J]. Microbiology, 1994, 140（1）：19-26.
[2] Xu F, Shin W, Brown SH, et al. A study of a series of recombinant fungal laccases and bilirubin oxidase that exhibit significant differences in redox potential, substrate specificity, and stability[J]. Biochimica et Biophysica Acta（BBA）-Protein Structure and Molecular Enzymology, 1996, 1292（2）：303-311.
[3] Xu F. Oxidation of phenols, anilines, and benzenethiols by fungal laccases：correlation between activity and redox potentials as well as halide inhibition[J]. Biochemistry, 1996, 35（23）：7608-7614.
[4] Gianfreda L, Xu F, Bollag JM. Laccases：a useful group of oxidoreductive enzymes[J]. Bioremediation Journal, 1999, 3（1）：1-26.
[5] 孙东梅, 蔡称心, 邢巍, 等. 含铜氧化酶在活性炭上的固定及直接电化学[J]. 科学通报, 2004, 49（17）：1722-1725.
[6] Dekker RFH, Barbosa AM. The effect of aeration and veratryl alcohol on the production of two laccases by the ascomycete Botryosphaeria[J]. Enzyme Microb Technol, 2001（28）：81-88.
[7] 万云洋, 杜予民. 漆酶来源与应用[J]. 中国科技论文在线, 2011（6）：1-11.
[8] 张素轩. 半知菌分类的进展[J]. 南京林业大学学报：自然科学版, 1980, 1：95-108.
[9] 郭尧君. 蛋白质电泳实验技术[M]. 北京：科学出版社, 1999：175-184.
[10] Hao J, Song F, Huang F, et al. Production of laccase by a newly isolated deuteromycete fungus Pestalotiopsis sp. and its decolorization of azo dye[J]. Journal of Industrial Microbiology & Biotechnology, 2007, 34（3）：233-240.
[11] 姜庆宏, 赵敏. 新月弯孢霉产漆酶培养条件的优化[J]. 农产品加工, 2009（3）：62-64.
[12] Liu Z, Zhang D, Hua Z, et al. Improvement of laccase production and its properties by low-energy ion implantation[J]. Bioprocess and Biosystems Engineering, 2010, 33（5）：639-646.
[13] Munoz C, Guillén F, Martínez AT, et al. Laccase isoenzymes of Pleurotus eryngii：characterization, catalytic properties, and partic-ipation in activation of molecular oxygen and Mn 2+ oxidation[J]. Applied and Environmental Microbiology, 1997, 63（6）：2166-2174.
[14] Yaver DS, Xu F, Golightly EJ, et al. Purification, characterization, molecular cloning, and expression of two laccase genes from the white rot basidiomycete Trametes villosa[J]. Applied and Environmental Microbiology, 1996, 62（3）：834-841.
[15] 万云洋, 杜予民. 漆酶结构与催化机理[J]. 化学通报, 2007, 70（9）：662-670.